Vanos noisy

[rstoughy]

Looks (and sounds) like I have a Vanos issue with the red car. It sounded like a sticky starter to begin with however I had someone else start the car and realised the noise was coming from the front. Went round with the stethoscope and you can hear it clear as day cracking away inside the unit.
Its like a metallic clunk, I likened it to hitting a shovel with a hammer.

So what's my options then?
Any ideas?

[adem.csl]

MIGHT be a blocked oil feed pipe!!!
You can start the car and loosen the bolt ontop of the vanos feed pipe just to see how much oil comes out!
The filter on the valve could be blocked!!
image.jpg
No 4-5-6

[NBTBRV8]

BMW do exchange ones now.

[rstoughy]

Another thing I noticed was the car seemed down on power when pulling out the Hairpin in 2nd. when up in 3rd the car would all of a sudden "perk up" a bit once up in the top 1/2 of the rev range.
Don't know if this has anything to do with it but just seemed weird as none of this was noticed while over in Germany.

[adem.csl]

Originally Posted by rstoughy

Another thing I noticed was the car seemed down on power when pulling out the Hairpin in 2nd. when up in 3rd the car would all of a sudden "perk up" a bit once up in the top 1/2 of the rev range.
Don't know if this has anything to do with it but just seemed weird as none of this was noticed while over in Germany.

How much fuel in the tank at the time?1/4 tank?sounds like fuel starvation it flows the fuel to the left of the tank causing a surge so loss in power as it uses whats in the filter.once you straighten up it flows fuel to the right side and you get power back.
How much oil do you run on track?
6.5 ltr is the amount but if you add half ltr it stops oil starvation on hard corners!!
Take the oil pressure switch out n check oil pressure in that case!you may have a damaged oil pump running it dry
I ruined my followers starving the oil to the top!!

[rstoughy]

Cheers Adam,
I run with 1/2 tank of fuel at the start of each run so that shouldn't be the issue.
As for oil its just on Max line on dipstick.

[0-60Motorsports]

Originally Posted by rstoughy

Looks (and sounds) like I have a Vanos issue with the red car. It sounded like a sticky starter to begin with however I had someone else start the car and realised the noise was coming from the front. Went round with the stethoscope and you can hear it clear as day cracking away inside the unit.
Its like a metallic clunk, I likened it to hitting a shovel with a hammer.

So what's my options then?
Any ideas?

http://www.cslregister.com/forum/showthread.php?t=12029

get all beisan parts and do a rebuild! Bulletproof your vanos and make sure you change upper chain guide too.